Laserfiche WebLink
GENERAL INFORMATION <br /> Thank you for purchasing your Low Pressure Sewer <br /> Basin System. <br /> Before Installation: A DANGER <br /> This manual contains important information for the Risk of fire or explosion. Do not smoke or use open <br /> safe use of this product. Read this manual completely flames in or around this system. This system is not <br /> and follow the instructions carefully. Reasonable intended for use in hazardous locations per NFPA 70 <br /> care and safe methods relating to the installation and National Electric Code. Consult factory for optional <br /> operation of this product should be practiced. Check equipment rated for this use. <br /> local codes and requirements before installation. <br /> A DANGER <br /> A DANGER Cutting Risk. Risk of serious cutting or amputation <br /> Risk of electrical shock or electrocution. May exists. Disconnect all power sources prior to servicing <br /> result in serious injury or death or fire hazard. Installer pump or grinding mechanism. Pump may start without <br /> must disconnect all electrical sources prior to installa- warning. Grinding mechanism is extremely sharp. <br /> tion. Only qualified personnel may install this system. Use caution when handling grinder mechanism. <br /> NFPA 70/National Electric Code(NEC)or local codes <br /> must be followed. System must be properly grounded DO NOT THROW AWAY OR LOSE THIS MANUAL. <br /> according to NEC. Keep it in a safe place so that you may refer to it often <br /> DANGER for the continued safe operation of the product. <br /> Biohazard Risk. Once wastewater source has ®CAUTION <br /> been connected to system, Biohazard Risk exists. Delta Environmental Products does not recommend <br /> Installer(s)and/or service personnel must use proper basins with base/bottom diameters greater than 30" <br /> Personal Protective Equipment and follow handling when installing a simplex positive displacement pump <br /> procedures per OSHA 29 CFR 1910.1030 when (D1 P20)system. When operational conditions require <br /> handling equipment after wastewater source has been a basin with base/bottom diameter of greater than 30" <br /> connected to system. it is necessary to perform a sludge pump out on the <br /> basin at least once per year to prevent any potential <br /> septic/odor conditions. <br /> INSTALLATION SKILL REQUIREMENTS <br /> The installation of a basin system is a specialized skill, These instructions are meant only to be an installation <br /> which requires individuals with the basic understanding guide;therefore, unusual installation conditions not <br /> of excavating, pipe fitting, and electrical wiring. covered in these instructions require experienced <br /> personnel capable of utilizing reasonable engineering <br /> principles for the installation and operation of the system. <br /> EXCAVATION INSTRUCTIONS <br /> A DANGER <br /> Excavation Location Excavation for <br /> Excavation location shall be made according to Basin Systems: <br /> local codes and regulations. Check with local utility Effect appropriate excavation based on size of the <br /> companies for the location of underground utilities basin,desired entrance point of the influent line, and <br /> prior to excavation. Care should be taken to avoid entrance of power connection. <br /> buried utility lines, piping, and other buried structures <br /> and foundations. Failure to follow these instructions <br /> may result in serious personal injury or death. <br /> 2 05625-459-1 <br />