Laserfiche WebLink
shut off then restart. On a return trip I messed with the low float. Could not reproduce the <br />problem after that but not convinced it is gone. Not sure if a stop float cord being wet inside <br />would do this, but when I removed it out of turbulence and above the water I noticed a couple <br />knicks in the cord, not through the jacket. <br />Recommendation: When Vince is out for the electrical stuff on this summary he can go <br />through it and determine if there is a real issue. <br />Vince will look at on 1013 @ 9AM <br />LS# 12: Both pumps have worn volutes and rotating wear rings. Both pump's stationary wear <br />rings are shot. Wear rings shot. Volutes worn. Both volutes could survive another year. Station <br />needs to be cleaned. Floats are riding grease mat. <br />Recommendation: These pumps are 10 years old. May be a possible remodel for next year <br />— Replace both pumps - $23,140.00 <br />LS# 25: Pump no. 2 had milky oil; changed. Also has blow by. Pump no. 2 meggs bad and failed <br />the ohm test. Pump no. 2 needs repair or replace. <br />Recommendation: Replace Pump 2 - $11,870.00 (Note: Rebuilt once before) <br />LS# 29: Pump no. 2 overload bypassed - Amps are good - plenty of range on dial - bad overload <br />Recommendation: Replace overload assembly — Siemens Size 2 - $300.00 <br />Vince will bring one with him and install when out on 1013 <br />LS# 31: Pump no. 1 has light wear on the volute. Pump no. 2 has a worn volute and runs <br />rough. Pump no. 2 volute worn out. Bad bearing noises. Needs repair soon. <br />Recommendation: <br />A. Rebuild Pump 2 and install new volute — (seals, bearing, o-ring kit) <br />B. Replace Pump 2 - $11,870.00 <br />GS# 10: Both pumps have worn volutes. Both pumps' stationary wear rings and rotating wear <br />rings are shot. Both pumps have extreme wear on cutters and impellers - need replacing. <br />Recommendation: Replace both Pumps - $14,600.00 <br />GS# 12: Both pumps have sharp rotating wear rings and stationary wear rings. DJ wants a recessed <br />lock installed on the hatch. <br />Recommendation: Recessed lock box installed - $1,850.00 <br />Total cost for the red repairs = $53,130.00 <br />When the pump at LS25 or LS31 are replaced, we will cleanup a volute and impeller for <br />show and tell for the city. <br />Thanks <br />Pat <br />66 <br />