HomeMy WebLinkAbout2016-00156 - new gas line CITY OF ORONO * Z 0 1 6 - 0 0 1 5 6 *
, � 2750 KELLEY PARKWAY DATE ISSUED: 02/12/2016
ORONO, MN 55356-
(952) 249-4600 FAX: (952) 249-4616
ADDRESS : 1020 BROWN RD N
PIN : 27-118-23-42-0019
LEGAL DESC : LONG LAKE COUNTRY CLUB ADDN
: LOT 001 BLOCK 003
PERMIT TYPE : MECHANICAL
PROPERTY TYPE : RESIDENTIAL
CONSTRUCTION TYPE : GAS L[NE ONLY
VALUATION : $ 1,000.00
NOTE: NEW GAS LINE FOR LOG INSTALLATION IN EXISTING FIREPLACE
APPLICANT MECHANICAL 50.00
STATE SURCHARGE MECH(VALUATION) 0.50
FRANCIS,EDWARD MAIL-IN FEE 2.00
1020 BROWN RD N
LONG LAKE,MN 55356- TOTAL 52.50
Payment(s)
CHECK 228 52.50
OWNER
FRANCIS, EDWARD
1020 BROWN RD N
LONG LAKE, MN 55356-
AGREEMENT AND SWORN STATEMENT
The work for which this permit is issued shall be performed according ro
the approved plans and specifications,applicable City approvals,and the
State Building Code. This permit is for only the work described and does
not grant permission for additional or related work which requires separate
permits. All provisions of laws and ordinances governing this type of work
shall be compied with whether or not specified herein.This permit will
expire and become null and void if construction authorized is not
commenced within 180 days of the date of issuance,or if construction is
suspended for a period of 180 days at any time atter work has commenced.
The applicant is responsible for assuring all required inspections are
requested in conformance with the State Building Code.This permit may be
revoked at any time for due cause. ��Y )
,
��' C���, ,C� -_ ,� "�-'C-,�i'� �,��..�.�L ��_ / � Z/ � �`
�.- ;�
Applicant Permitee Signature Date Issued By Signature Date
�
' ��E1i/ED
" ��� � 1 ?016 FOR CITY USN:ONLY
City of Orono
j���� P.O.Box 66 Date Received: y����PermiC# ZO L�D'"(� �S�c
2750 Kelley Parkway
Crystal[3ay,MN 5��Q�QRQN� Approved By: _��Amount$:��' S�
Phone(952)249-4�6�0 Paa(952)249-4616
•.t �,
y �
F �
� �,�' CITY OF ORONO-MECHANICAL PERMIT
�K�S H�¢
(All Commercial pennits must be approved by the Building Official or Inspecror and/or Fire Marshall)
GENERAL INFORMATION
1. You may apply for mechanical permits by mail or in person at the City offices. Applications will
be reviewed and a permit will be issued within two working days.
2. Permit cards will be sent by return mail after a review is completed. PERMITS ARE NOT
VALID UNTIL YOU RECE[VE A PERMIT. WORK MUST NOT BEGIN UNTIL THE
PERMIT CARD IS POSTED ON THE JOB SITE.
3. Mechanical Desiens—Complete calculations,details and specifications are required for each
heating,ventilation,humidification-dehumidification,and air conditioning installation including
heat loss/heat gain calculation,design temperatures,equipment ratings and identification as to
type,manufacturer and model. Data shall be presented on form provided.
4. When any new construction or remodeling is involved,a separate building permit must be
obtained.
5. All work must be done in accordance with the Uniform Mechanical Code/State Building Code
requirements.
6. All work inust be inspected(rough-in and final). Call(952)249-4600.
(24-48 hour notice required)
7. House Heating Test Record must be submitted before final.
TYPE OF PERMIT
(Check All That A ly)
[�C Residential ❑ Commercial(Approval Required)
�f New ❑ Additional ❑ Repairs ❑ Replace
Job Site/Owner Information:
Site Address: ��ZU /V 13!-c�w/� ��
Owner: �4Jc,rJ ��'Uc/�(;,lS Mailing Address: �UZO /V �rG�✓!1. 2J
c�ty: L��� �u 4� zlp: SS3S`�
Home Phone: 6�Z— ��CI-j(> `�Z. Alternate Phone: ��
Contractor Information:
Contractor: /l��iitG Contact Person:
Address: State Bond#:
City: Zip: Expiration Date:
Phone: Alternate Phone:
❑ Insurance-Current:
1
y
MECHANICAL SYSTEMS BEING INSTALLED
Note: All Geothermal Systems will now require a Site Plan& Review by o�ir Building Official.
IS THIS GEOTHERMAL? ❑ Yes 0 No
HEATING SYSTEMS
Quantity:
Make:
Model:
Fuel:
Flue Size:
Input BTUs:
Output BTUs:
CFM:
COOLING SYSTEMS
Quantity:
Make:
Model:
Tons:
H.Power
FIREPLACES
❑ Gas Factory Fireplace Brand Name:
❑ Wood Burning Fireplace
❑ Wood Stove Model No.:
❑ Wood Stove with Flue/Masonry
VENTILATION
❑ Na Kitchen Exhaust duct recirculating cfm
❑ No. Bath Exhaust(must have duct outside) cfm
❑ No. Other Fans: Locations cfm
FUEL STORAGE (Must be approved by Fire Marslza!l ifproposing to abandon tank in place.)
❑ Installation ❑ Removal
Fuel Oil: gallons ❑ Underground ❑ Inside ❑ Outside
LP Gas: gallons
Other:
GAS LINE ONLY
❑ Outdoor Grill � Other/List What&Where: �/�� /05 !/l5�..��r� �,�
2 G�u lS�-(',/�j ��'c.�lw..�.
v
,
.
P�RMIT FEE CALCULATIONS
1. CONTRACT PRICE * is 1.25%of contract price with a(Minimum Fee of$50.00)
�/Gov X .o�2s $ SU . L�
(contract price) (minimum�50.00)
2. STATE SURCHARGE
� IU(/(J x .0005 $ • S-�
(contract price)
3. POSTAGE&HANDLING(Only on Mail-In Applications) $ 2.00
4. TOTAL PERMIT FEE(Add Lines 1-3 Above) $ �2• ��
• * CONTRACT PRICE or JOB COST means the actual or estimated dollar amount charged for the
permitted work including materials, labor,profit, and other fixed costs. It is the amount to be charged
to the customer for the work done. If any material,equipment,labor or installations are furnished by the
owner, tenant or any other party, the reasonable market value of such items must be added to the
estimated cost or contract price for permit fee purposes. In the event that there is a dispute on the amount
of the job cost, the City may request the submission of a signed copy of the actual contract.
MECHANICAL PERMIT APPLICATION AGREEMENT
The undersigned hereby applies to the City for issuance of a Mechanical Permit, agrees to do all
work in strict accordance with the ordinances of the City and the regulations of the State of
Minnesota,and certifies that all st ements m on t ' pplication are complete,true and correct.
Applicant's Signature: Date: � — �j�'Z���
3
. /OZ,� � ��o�.�. �{��d
• . � Installation Read this manual before installing or operating this appliance.
Please retain this owners manual for future reference.
H E A RT H IrH O iM_E Instructions Congratulations
Congretulations on selecting a Firesltle gas log set—en el- Thls ownefs manual should be retained tor fuNre reference.
nstallatlonanCs ofthis egantanddeanattamatrvetobumingwood.TheHearthB Wesuggestyoukeepitwdhyourotherimportentdocuments
MOdB�3: appllance should be pertormed by Home TeChnologies ge5 log Set you heve SeleCtetl i5 Ee- anC protluct manual5.
Ifi d I.Hearth BHome signed[o provide the utmost�in safery,rellablltty,and eifi-
SP18NG,SP78LP,SP24NG, qual e personne rne intormation contained in this owner's manual,unless
SP24LP,SP30NG,SP30LP, PFS' Te�n�oioq�e::�gqe:isNFi oert�eea c�e��y. �otea otherv+ise,applies to all motlels an0 gas control sys-
or factory-tralned protessionals,or qs Me ovmer of this new gas log se[,you'll want[o read tems.
STSPIBNG,STSPIBLP, � �s 2 Vecnnic��ans super- ana caremny rouow an or me instmaions con�ainec�n tn��s
sed by an NFI Vour new gas log set will give you years o(tlure0le use antl
STSP24NG,STSP24LP certifled profes- ��,,,� Wa^^s manual.Pay special atteirtion to all cautions anC trouble-hee enjoyment Welcome to[he Hearth 8 Home
FiresideBumedHeaRhKits sional. � 9s� TechnologlesfamilyofapplianceproduMs�.
We recommend thet you rerord fhe lollowirg pertinent
Homeowner ReferenCe InformetiOn inlametion ebouf your ges log set:
Check with your local building code agency be(ore you beg�in installation to ensure compllance wtth local cotles,Including
the need for permtts and follow-up inspections.If you ancounter any problems regarding code approvals,or if you need
clarification o(any o1 the instructions containetl�ere,contact the Tac�nlcal Services DeDt.,Hearth 8 Home 7echnologies Model Name-. Date purchased/installetl�.
Inc.,phone tE88�273973 or 1-800-927E841.
Senal Number: Locatlon on appliance'.
CAUTION
DO NOT DISCARD THIS MANUAL O Dealerenip purchaeetl trom�. Dealer phone:
� Important oFerating• ReaE.untleretand• Leavethlsmanualwtth �/SO'T' Noles:
� antl maintenance antl touow these party respons�ible tor C,q O�,
� mstn,cnons incivaea. instructions mr sste ose aoa operaeon. �P�
nstallation and
o eretion
A WARNING A WARNING Listing Label Information/Loeation
The model inbrmatlon regartling your specific gas log set can be fountl on the reting plate.
If the infortnation in these instruc- Mori oo Nor roucH.
tions is not followed exadly,a _ sEVERE BunNs mar nEsu�r.
fire may resul!causing property CLOTXING IGNITION MAV RESIILT. MOEeI p\ Gas TyOe Senal p
� damage.personal injury,or death. Glass anE other surtaces are hot during + \ �
�����k.6'� operation antl cool down. MOUEL NO: y SERIAL N0:
• Do not store or use gasoline or other flam- �V INPUT RATING: WS ttPE:
mable vapors and liquids in the vicinity of . Keep cnndren away. IA4x.INLEt PRESSURE: incMc W.C.
thi5 of efly Othef epplieflCR. • CAREFULLV SUPERVISE children in same room as � MNiIFOLD PRESSURE: inches W.C. �-�
•What to tlo if you smell gas: avviiance. � � � �
Alert chiltlren antl atlults ta hazartls of - ., �
- Do not try to light any appliance. temperatures. � "`""T"";��;s;`„";N0°;'"'
- DonottouchanyeleGntalSwitGh.Donot • Keep clothing,turniture,tlreperies antl h u,p�,�k,,,es,ucs�zx�.coe-mizcsezsswua«onwe
use any phone in your building. combustibles away. �„ y�gM��
- Immetliately call your gas supplier from r,is ��iarn,e�� d TMh�4�.
a nei hbor's hone. Follow the as ��P�� � ���
suppller'sinsWaions. 8 WRRI�G:yy�qyylan�nitoAd/IMh Wz^Nx^D.�
I�ni9fireqxe aYY.
- Ifyoucannotreachyourgassupplier,call �nmecommonwea¢normaeeaenusena: rnpacewnriymuMhbmapamarv.alopnrprom.�a�prr
iheflredepartment. qrq�y� �y�qp�ay�p��yMpryp��ryp��K�
• 1�518118ti0n Bnd 5¢�viG¢rt1u5t b¢peffOrtllBd ' T�is appliance must be installed by a licensed plumber ���
or gas frtter.
by a qualifed installer,service agency,or . T�e�nimney nue eamper,when used wah gas iogs,wiii MAN���G:ImpraqrMt�lylataqushnntnentlartwWua
the gas supplier. oe weiaea open or compieteiy removed. maianceca,can.papenyeanayepenmdmMry«imsaw.
• A CO tletaMor shall be Installed in the room where the ��b�0'"���HO^"�m�R°�����.
Note:Anarrow(y)founEinlheteztslgnRleschangein applianceislnstalletl. ����^"�a7���1'a4�b��.��
cantent �'Y Q�����'
Hearth 8 Home Technologles•FlreslCe Bumer/Heart�Kits•4004-3'IB•Rev F 52013 rth 8 Mome Tec�n les•Flreslde Bumer/Hearth Kits•4004318•Rev F 52013
, T', ! � � �'I
�',:�,,�`,5:�1�; �:�r u�we �,
��;��::���:c �:�y c��Jrono �
Qi�� � � Ie (� 1 Listing and Code Approvals
�..�...,..�....
- A.Appliance CertiTcation
The Fireside BumerMearth Krts have been testetl anC I�isted A WARNING
Revievver �'j' In the U S in accorEance with AN51 Z37.BOb-1012(Gas Improper Installation,aEjustment,alteretion,service
Log Set).In Canatla the Gas Log Hearth Krts have been aintenance can cause injury or property tlamage.
1 Lirtin Cotle A pproved In accortlance wt�CSA 2.28b-20t2. or m
g an pprovals tested and a Refer to the owner's information manual provided with
A. Appl arke Cenifiration .... ....a They have been listetl Dy PFS Test Labs for'nstallat on and this appl ance.For ass'stance or aEdR onal information
B. Tebk 1 ..4 operation in the Unded States antl Canatla as tlescnbetl'in consult e quel fed'n5taller servce agency or the gas
C. Tabk2 ..... ...... ...........5 MeselnStallationantlOperatlnglnshuctons.Allcomponents suppiier.
2 Getting Shrted are UL,OMNI,or CSA safery certifieC.
A. 5¢e N FireDox...............................fi Checkwtth your local building wde agency pnorto installing
B. NegetrvePrassure. .... .....6 Mis appl-ance to ensure ComplienCe with loCal CodeS,
c T�ise�e s�PPrasr�oa,a _ _s ��cma�oy tne need ro�pem,n a�e ronow�P��sPe�c�o�s A WARNING
D. Inspep Me Appliarwe erk Comporierta... ...6 In the absence of locel cotles,comply with M1e National Fire Riak
E. Compmenb ofthe Ges Hearth K't...............7 Fuel Gaa CoAe,ANSI Z323.1{n¢�Etlition in[he U.S.�, Ezhaust Fumes Risk
3 Appliance P paraho 'n Canada the CAN/CGA Bt49 Installahon Cotles.If any —
n. cas5 pptyConrwcn n „e asssTance s requred dunng�nstalla[on please contact DONOTusethisapplianceasaYent-hee
8. Co rt t Left Sbe Gas P pi�p.... ....8 your local tlealer or call Me Techn-cal Serv ce5 DeDertment heater.
C. Ge P re... ,,g at 1�88�27 3973 or 1 B00 927E841. 1S1 The fiue must be permanently open.Refer
e ins�auanon inmucnona B.Table 1 — co Taeie�.
n. i��ainne�mee�scoa_ . _io .
e. i�raii�n�e��naa�w.�mmy................io �. ..�.o �o�.�o .�..a �a.� �� s��P ...,.� s.sP,.�a .r� ,n�.�>
C. InetelltMGrete.. ...................10 irvwanrxwmn rva Aaoin. ei000riae mauaia� eo.000in.e �aoaa�.n
D_ PheeSaMaMRoekwool.....................1� �v .aaooi��� �ocroi�i� m000ina ss,000rin ae.oeo�mz
E. In&elltlieLops.. .......................11 r�a�eviww.ix.�n >eio�e asi.o�e a.ei.o�e 3.nio+e a.ei.o�e
F. AdP++��BumerFlema......................it "<�K°� �v �ioioosr �iorom� i�oraan i�orom� iiaiom�
G. InepecttheVen�irq5y�tem....................11 c�imnr,....,. wi iaoi.ma iaimr �oimx w.ai.ro1 +oi.aw
5 OperatlnpinrtrucNon '"-'"��"P' o�c oro ora oro o�oas
a a e
A. LipMirpinshuctrona.. .................12 .imwnnwunx.�n a.eiwe asia�e ieia�e a.ein+e ani.o+e
B. GleeaDoor . .......................13 ��""' oic oro oro �oroo aiom
e �v �i oar �. m-r �i m-r i n ii �
C ImVOReMSeleyuertle........................13 airww. w� y1qi�� I�m��e� t��fl.�n la�l.�m t�%�ei
B M�IMaining and Servicing the Applimea '"r'"'" i= .,,o �uz�wae ua�oe z
A. SemarqVovAPd'�arim.. ..14 �nn fern.� zai��� Nies.� v�es. ai�ae.� azrios� - - Niee.� Hres�
B. CkeniryVourApplience .... .... .14 �^^osti� -
C. Mnwllrupec9on......................... .14 wyn iu. iro i�¢. ,..s �m. iw �erw.i �eias� ieiw.� �ei�sr
t� e �c s ie > >e� � m e x e
D. TroubleMootinp ............................16 r.wMow•M�• aimie v�zs�E �ersc� wr�os� eeiai�.x sei3�.: aa�te�.e �si:5is �eraw.� �erws�
7 ReferenceMateriala °^"•^'""^
A. RadacemerRPerte.......................1511
B. VJartaMy.. .......................1}20
c. con.�emro���o�_____......_..._...zi A WARNING
CAUTION
Asphy%iation Risk
Sharp Edges S11 Thls appliance produces carbon monoxitle
• Wear proteMlve gloves — (CO).
antl safety qlasses during • Thefreeopeningareas(insquareinches)
installation. of the chimney damper as s�own in t�e
tables must be met.
• User must make sure tlamper is IockeE
open.
• The Installer is responsible ro ensure
proper ventilation o(flue geses before
appliance is used.
Flre needs to dra(t properly for safe
operetion.
Hearth 8 Home Technologles•FiresiOe Burner/Hearth Kits•40043'IB•Rev F 52013 3 4 Heartti 8 Home Technologies•FiresiEe Burner/Hearth Kits•4004-318•Rev F 52013
A WARNING •
2 GettingStarted HeartnaHomere�h�omy�esa�s�ia�msany
A.Size of Firebox _ responsibiliry tor,anE t0e warranry wlll be
F�v\In n�I1ilt Fir.pla.��Fm nreninp\rea idCLlinne�Ilm�per Fw�'.niinp(bmbu��i�w voided by,[he following edion5:
VroJun.^Fl���n Ik..i�.e�ppl�.�.�.�..F��r I��.i�,ll.�w���In 4diJ Fuel PurninK F'ircpl�iw.. See Table 1 in Section 1.8.
aM,iunnin�n W�.ikBli'mr� 9 Inst'Isyetemacomponent ny damagetl appliance o�
8.Ne ative Pressure
������, Negative pressure results from the Imbalance of alr avail- Mo0lfication oft�e applianca or vent system.
p���� N �„ ,,, ,,,, ,,, a„ .� i�., ii� .i able tor the freplace ro operate properly.Causes for this Installationotharthanasinstruc[edbyHearthBHome
�imGalance�inclutle. Technologies.
�Tim�.� • Ex�aust fans(kitchen,bath,etc.). Improper positioning of the gas logs or the glass
H�iWit• \IMlwi�(�tNnR••�p.in.) . E00l.
Range hoods.
1°� • COmbustion air requirements(orfumaces,water heaters Instellation and/or use of any com0onent part not
. "e . . .. -�' -. �"= ... antl ot�er wmDustion appliances. approveE by Hearth 8 Home Technologies.
, . . , ..� ,,, . ,� • Clothe5 dryers. .4�y sueh action may cauae a fire huartl.
_ _ _ • Locat�lon of return-8ir vents to fufneCe of 8ir
' 'o oo�art�o��oy 0 WARNI�NG
` - • � �' `" "'" � • Imbalances ofthe HVAC alr�andling system.
. >- .. , , ,. v.� . • Upper level air leaks�.recesseE lighting,ettic hatc� n pec pp ia componen s or
opening,tluct leaks. damage.Damaged parts may impair sate
. „ „ . .• .. . . _ operation.
� �V :'^ :` ,I± ' + +n, +' C.Tools and Supplies Needed • oo No7 instau damaged components.
`Hnpm�..wmlieannn�i.pMcnvniv.�Wihemimmimih<igh�..lulni � • OoNOTinstallincompletecomponents.
•�k„„a,,,w.,m,,,,m,,,,,,r,.,,,,,._,w,,,,i;,��,«,,,.,,�„�M,,,,�,,,�„„��� Tools antl supplies normally requlred for�installatlon�. . Do NOT Install substttute components.
Pliers Report tlamaged parts to dealer.
Phlllips screwEmer
Tape measure E.Components of the Gas HeaRh Kit
For F.nor.B��li Rr.p.a�,e..�op���R:�.n�r cn�m�n n.�.�.ra���m��o_c��n�.r�� Crescent wrenches The Firesitle BumerMearth Kd consists o(the following�.
rNa�a.e.�a.�w.i�,.�.a��.�a,r�.��,i.uNw���s�d r�d u��ing Pin•plaa�.. Gas s�utoflvaNe • Bumer/Pan Assembly
Non-Corrosive leak check solution • Grote Assembly
M.� W4 kNT1�lFr 3/4 in.wrench,7/16 in.wrench • Glawing Embers
Futnn � � • SanE(NGonly)
n.;n' x �o w ro � eo � ioo i io ..0 D.Inspect the Appliance and Components • vermicuiae(�P oniy)
• Remove the con[ents from Me arton.Attache0 ro Ne • Lava Rock
j���"^"�`I ' �"" bumeraretagsitlentifyingt�emanufacNrername,senal • DamperStop
��.ii.�gni•�, Nm+s�op.bnF��iSq.h.) - .I iM��"'" umber,model number(including gas log s¢e),B7U • LogSet(soltlseparately)
���' ra[ings,gasrype,etc. • REMKit-Tocomertbumertoavanablefiamewtthremo[e
°' —� � ' - � • Review the attac�etl tags before proceeding.Ensure control(soltl separetely).
_, . , ,i.; ,,, , � -�•�KS _ that all minimum freplace tllmension requirements are . LSK100KIt-Toconvertbumertoanon/offassemblywhh
. y , . ., �'i- .' achieved us�ing Table 1-n Section 1.8.See F�gure 2'I. a log switch(soltl separately).
� � � '� ' It� Ensure the gas type provtletl in the fireplace coincide
._ ,..o _. ixi _:� . �i. .� uo w� i:io .P��1..�� .. , wiMthegasrypemarkedonthetag.
, m , ,, , „: • A WARNING
�. �.. �,. �+ z:i :�� ?n 1 ��.: . igure 2.1 Measure Fireboa Keep appllance tlry.
-, „ � �i, 4 i�, _ • Mold or rust may cause
•�n:iµhto(ranhannwiopadumM�'aiHlpv:mmin,�.unlwiphiuluF � • Wetermaytlamage ontrols.
t'I�nslwu�x mryenrcis.�in��I.�riMpn'enhrqhi�anJiiµ�u�n�e�.
' �'��IunnmerkN�'Ala<inpui wrtey�rkL.i.�Jrmerimumill.m�ahl�vy�nrmr�kNil lvil�x�hesi�rnlvy�hi
A WARNING
� Do NOT use this aDPliance ifany pert has been unEer
water.ImmeEiately pll a qualifietl service technician
ro Inspectthe appliance and to replace eny part otthe
control system and any gas control which has been
��eer wacer.
Hearth 8 Home Tec�nologles•Flresitle BumBr/Heerth Kits•40�4-318•Rev F 520'13 5 6 H88Rh 8 HOme Technologles•Flresitle Burner/Hearth Klts•4004318•RBv F 52013
Note:A Ilstetl(antl Commonwealth o!Massachusetts • GasSupplyPressure:Minlmuminletgassupplypressure
A WARNING approved)1/2 In(13 mm)T-handle manual shut-off valve A WARNING must be 4 5In W C for netural gas or��in W C Por LP
and flexiDle gas connector are connecteC to the 12 in. � . gas for the purpose of Input adjustmant'Maximum inlet
Shock Riak Fire Riak gas pressure must not exceed 7.0 in.W.C.for naturel
(13 mm)rontrol vaNe Inlet. P gas or 13 in.W.C.for LP gas.The gas line supplying Ihe
�1 Fire Riak — E:losion Riak
Use ONLV optional accessories approved ' Ifaubatitutingforthesecomponarrts,pleaseconsuH • Gas builE-u0 during line purge may appliancemustbesumc�entsizetofum'�shth��propnate
forth's appl�ance. local cotles for ompliance. �gn�te. suDPly pressure t tlie�pl anCe hie opetatng'n the
� : Us-ng I�t tl cessor'es vo'tls � : Purge s�ou10 be perto tl by q I fetl 'H'gh'setting.(Mirt m m I ID of 1/2'.required ithe
warranry. tec�n�can. lineslongertha 20R.).
usng fst da cessodesmayresun 0 WARNING Ensureaaequatev ti ti . GasLinePressureTesta rt rmp t staccoming
�inasafetyhazartl. FveRiak • EnsureLierearenoignitionsourcessuch tostateandlocalcode(fpressureexceadsl2in.psi[3.5
• Only Hearth 8 Home Technolog�ies Exploaion Riak as sDarks or open flames. kPaJ)betore apPliance is conneMetl.Be sure to release
approvetl accessories may be used Veriry inlet pressures. air pressure from the gas line before connection Is matle
safely. `,J�,• High pressure may cause over flre C.GasPfE55ufE rotheappliance.Excessivepressurewilldamagethegas
��� wndttion. Proper input pressures are requlretl for optimum appllance control and may cause a gas leak.
�"'( Dertormance.Gas line s¢ing requlremen6 naed to be made • Gas Leak Test Make sure the gas connections are tight.
Low pressure may cause ezDlosion.
Applianee Pf2paration ' mllowing rvFPAs7. 7um on tne gas ana coat eacn jomtwdn a non<orrosive
Install regulator upstream of valve If Ilne ges leak check solution.Air bubbles will form indicating
Note:Have the gas supply I�ine�installed in accor- prassure is grea[er than 1/2 psig. any leaks.DO NOT USE A FLAME OR ANY TVPE OF
tlance with local bu�iltling cotles,If any.If not,tollow B.ConVert to LBR SidB Plpiflg A WARNING IGNITION SOURCE TO CHECK FOR LEAKS.All leaks
Fire Risk must be correcte0 before proceetling with installation.
NOTE:YOu will n¢ed a kit to change to ExplosionRiak • Theappliancemustonlybelnstalledlnasolid-/uelbuming
lek SidE piplflg.SeB page 18. Hlgh pressure will damage vaNe. fireplace wifh the flue tlemperdampeCopen.
DisconnectgassupplypipingBEFORE • Theminimumpermanentfraeopening(Insquareinches)
A.GeSSu I Connection • Removebiackca homleftsitle. pressuretestinggaslineattestpressures thatmustbeprovitletlbythefireplacechimneyortlamper
PP Y D aGove 12 psig. to vent the Mue gases is proviCeC in Table 1.If Ihe hee
A3/BIn.flaretlfitting�asbeenlnstalletlonthegasvaNe • Removetwopilotheatlscraws. • Closet�emanuals�utofrvaNeBEFORE openingissmallerthanthesDecifie0area.tlonotusethis
�inletatthehctory.Enwrefitlingsareoftheappropnates¢e • Removetwopilotbracketscrews. pressuretestinggaslineattenpressures aDPliance.
antl rype on the gas Ilne connection.If Ne tubing�as to be • Detech Mermocouple antl pilot hom control vaNa. equal ro or less than 12 psig. • T�e tlampar ust be removed or fixed in a manner In
cut to length be sure ro use[he Droper cutting antl 1laring . RemoveMecontrolvalve homt�e rightside ofthe Durner whlch will secure rt open.Some jurisEic[ions require the
tool.Also,be careful not ro crimp the tubing whlle bending.If pan and reDlace on left,upsitle tlown. damperto be removetl or pertnanently welCed fulty oDen.
me t�o��q eacomes c�mpea.ao ooe�:e mr���:e�uaeo� . A WARNING cneck w�tn scate aoa moai ooda:.
Note:Prwr ro installing the valve,use Tetlon tape or joint
A WARNING ompountl on the male threaCs CMELK FORGAS LEAKS Be sure that[he chimney Is Complately unOEstruGted to
Fire Riak re proper ventilation of flue gases Induding carpon
LP Only — monoxlEe(CO).CO(a polsonous gas)is tasteless,
Gas Leak Risk E:ploaion Risk otlorless,calortess antl undetectable without proper
• Support control when attaching pipa to ' Reinstall pllot bracket on left sitle of bumer. Asphyziatian Risk ment.
prevent bentling gas Ilna. • Reinstall pilot assemblyto pibt bracket • Check all fittings and connections. aqulp
• ReatteCh pilot tube antl thermocouple to ron[rol vaNe. • Do not u58 ODen flame.
Reinstall black cap removetl hom left sitle of bumer t0 • ARerMe I tellatiOnlsCOm Iete,
Joint compound to Teflon[ape must be used on all threadetl � gas Ine ins p
male connections to ensure a tig�[seal. right sitle. 14 all connettions must be tightenetl and
• Install vaNe shieltl. Checked for leaks with a commercielly Hlgh Altkutle Derete
vallable,non-Corrosive leak check IntheUSA,inputBTUshallbederated4%(OneOri(tCes¢e)
0 WARNING NaturalOnly solution.Besuretonnseoflallleakcheck per1000teetforattduCesaEove2000feet.InCanada,input
Fire Riak • Install new pilot bracket on left siEe of bumer. solution following testinq. BTU shall be tlereteC 10%(two orifice s'aes)at attiNtles
— Exploaion Riak • �nstall new pilot assemby ro pilot bracket. Frttings antl connec[ions may have loosenetl from 2000-4500 feet.
,�I 'Penanel Injury Risk • Attach pilottube anE[hermocouple to control vaNe. tlunng shlpping anE handling.
��/An explosion coultl occur If a connection is ' ��stall black cap removetl hom left slde of bumerto nght
r c maae a��e�ny ro an���ey�iacea v�oPa�e��P� side CAUTION
caok • i�sean�atie:n�eia 0 WARNING
Prevant accidental epDliance operation when not
Left side piping when finished Fire Risk attendad.
Note:A �tl'E al manual shutoff vaNe(no[suppl ed)is � — Explos�on Riak Unplug or remove batteries from remote control f
absent or if appliance will not be used for an e�Rended
reQuiredwheninstallingthisapplance.ThemanualshuroR py�-'' , I DoNOTchange[hevalvesettings. periotloftime.
vaNemustbelocatetlin syaccessblearea nomore � "_ � ' Thl valve has Eeen preset at the
than6feetfromtheappl'ance. . �"" ��n, Property damage possible from elevatetl
• Cnang�ngvaNesetGngsmayresuttlnfre temperetures.
� hazartl or botlly injury.
Hearth 8 Home TecMologles•Firesitle Burner/Hearth Krts•<;,�,,»-;;'.o�'rte�a� ��1Jt:7 7 8 Hearth&Home Technologies•Flreside Bumer/Hearth Kits•4004-318•Rev F 52013
.
�} E.Install the Logs
4 Installatiofl IfIStfUCtIOf13 G.Inspectthe Venting System
Fi ure 4.2 Center Grote Over Burner Pan Install[he logs using the installation instruMions included The fireplace vaMing systam is designed antl constructetl to
A.I�Stell ShE De�11 Ef St0 wRh them. develop a positive tlow aEequate ro remove fiue gases to Me
P P • Lightthebumerasoutlinadintheoperatingsectian.Allow outsidea[mosphere.Seefreplacelnstallationinstructions.
• Open the damper to the lully open position antl secure rt the flame pettem to stabil¢e.It you are satisfietl wrth the A spillage test must be made before the installed
open with Me stop as shown in Figure 4.�. fiame pattern go to the neM step.If you want more or less appliance is lett wi[h the consume�
• If the tlamper stop doesn't fR your application,use a fiame around[he hont log,turn oflthe gas antl move the , Close all tloors antl wintlavs in the�ome.
permanent means that will keep the damper open at grate backward orfornard.
leastto the minimum vent opening as outlined in Table 1, • Once you are satisfed,tum on the gas and go on to Ihe � Llght the log set.
Section 1.B. ne�ct step. • After three minutes,test wrth a smoke matc�,smoke
• Arrange the top logs as shown in your log set up �antlle,sticklncenseoragaretteonelnchDelowMeropof
instructions.Lighttheburnerasoutlinedintheoperating �heopening�lintel)movingacrosst�efullwidth.lfspillage
'nstructions antl allow the flame to staDil¢e. (smoke Erawn Into the room)occurs,it will most likety be
Spread the lava rock around the outside of the burner ar the to,outsiEe comere.
D.Place SandNertniculite,Rockwool ne p
• Pour the sanE(NG moEels)or vermiculrte(LP moEels) pan on the fioorofthe fireplace.I(possible,croverthe gas P�ssible Cures if Spilling Occurs
intoMebumerpan.Sandorvermicul�eshoultlfollowthe connectorwiththecintlers.DONOTcoveranypartolthe ' ThetlampershouldbeNllyopen.
slope of pan,covering R end the bumer tube completaly. pllot assembly. • The fireplace opening nee0s to be reEuced by adding a
Crop Oanel across the rop unEer the lintel.
• TheairsupplyhomoutdoorsneeOsrobe'mcreesed.Open
Importank Cwer Me Dilot assembly to prohc[I[before the outsiEe air kd ifthe appliance is so equippeE,or crack
Installing Me send or vermicultte. . open a tloor or wintlow.
A WARNING If necessary,seek expert ativice Do not operete Mis
Fire Riek appliance.
Note:Use caution so vermicultte does not get inro the air Exploaion Riak Cleaning
mixer on LP motlels. Personal In u Risk Periotlic examination antl cleaning ot the venting system
Flgure 4.1 Damper Operation �ry of the fireplace should be tlone Eefore inttial use and at
Failure to Dosition the parts In accordance least annually by a qualified agency.
• Allow the sand or vermiculite to spill out the hont of the with Me tllagrems provitletl wRh the log
B.Ins}HII the BumeflPan As38Tbly pan and overthe sitles ontothe freplace floor. packages or failure to use only parts
The Eumer/pan assembly Is shlpped ready for ngM-hantl apDroved wtth thls appliance may resutt in
gas connec[ion.See Section 3.B.for lell-hantl mnnection. property tlamage or personal injury.
• Remove the existing�ap or ya:jet a::erooy noro tne 0 WqRNING
gas stub in your freplace.Clean t�e MreaOs using a wire
brush or steel wool.Apply Teflon tape or joint compountl Ezplosion Riak
to Me steel fitting anC attach the proviOeE Dress aCaOtar • Follow rockwool placement instructions Note:It your log set is tha bumFout type,place the rock
to the stuD. in thls manual. wool In the center of the logs to g��e a yiowm9 emee� A WARNING
• Place the Eurner/pan assembty in the fireplace.711e Dan • Replace rockwool matenal annually. e���
s�oulE De ceMered both hont to back antl siEe to siGe. Improperry place0 rockwool interteres whh Fire Rizk
• Bend the provi0ed gas ConneGtorto facilitate its installation proper burner operetion. _ Ezploalon Rlsk
behveen t�e bumer antl the gas stu�. Insped extemal vent cap regularly.
• Attach ona end of the gas connector to the Eass el�aw , F.AdjuSt thE Pllot Fleme • Ensure no debris blocks cap.
Lightly Dlace Eime-s¢ed pieces of rockwool evenly on top The pibt flame s�ould be a soft blue color and shoultl sur- • Combustible matenals blocking cap may
O�r safery pibt fitting.Attach Me oMer enC to the b2ss of Me sand or vermicul�e. rounC Me las[121n.ofthe therrtrocouple tip.Ra(er to Flgure ignite.
dapter at the gas tube. . ���pa��he pilot burner to ensure it is clear of any 4.3.to locate pllot aCjustment screw.If pilot fiame must be • Restricted air flow affects burnar
rockwool. atljus[eE,use a standard slottetl screwCriverto tum screw operotion.
clockwise to reduce flame or counterclockwise to increase
C.Install the Grate eame.
• The grate should be centeretl over ihe bumer pan,side ryote:For best resutts,tlo not pack Eown the rock wool.
to si0e.IfMe grete sits toward[he front ofthe burner pan, The placement o1 rock wool can have an effect on flame re 4.3 Pilot AduslmeM Screw
Me fiames will be larger mming t�rough the logs.It tha pattern anE may need to be adjusteE to achieve a desired _�
g2te sits toward the back of the burner pan,the ember appearance.
betl will be more prominent.Refer to Flgure 42. �
• The gas bums at the point of Me least resistance.In �
c e of an uneven tlame pattem it may be necessary to � �
adjust me matenals In the Dans(using an object such as .,.\\
a screwAnver)ro achieve the tleslretl eRect.
Hearth 8 Home Technologies•Fireside Bumer/Hearth Kits•4004-318•Rev F 520'13 9 10 Hearth&Home Technologles•Fireside Burner/Hearth Ktts•4004-318•Rev F 52013
B.G18S5�OOfS • Aqualifi8tlservlxtechnlclanmurtpeAorminrtelletion
Operatinglnstructions Ifyourfreplaceisequippedwithglassdoors andrepair.Theapplianceshouldbeinspectedandcleanetl
annualty by a qualifietl service technlcian.More frequent
��A.Li htin InStnlction5 • Glass Eoors s�ould be in fully opan position when cleaning may�e requiretl due to axcessive Ilnt,dust,pet
OR YOUR SAFETY,READ BEFORE LIGHTINC� ap0liance is operatlng �alr,etc tt is imperative that the control compartments,
lF THESE INSTRUCTIONS ARE NOT FOLLOWED IXACTLY,A FIRE OR IXPLO- Operating�m me<bsed position wili block the ratliant Dumers and air passageways are unobstmcteC tluring
heat output anC may cause Inromplete combustion of operation.
SION MAY RESULT CAUSIN('i PROPERTY DAMAGE,PERSONAL INJURY OR LOSS OF LIFE. the gas and wiil cause the gas varoe to ovemeat antl be _ Review proper piacement of logs,rockwool,lava mck,
A.This appliance has a pilot that muat be lighted by hand. When lighting the pilot,follow aamaged. santl orvermiculite.
thESeinStrUC210flSe%actly. - Checkthewiring.
B.BEFORE LIGHTING smell all around the appliance area for gas.Be sure to smell next to A WARNING - Ensure there are no gas ieaks.
the Floor beeause some gas is heavierthan air and will settle on the flooc Ensuretnenowofcombustion andverrtilation airis not
WHAT TO DO IF YOU SMELL GAS. Fire Riak obstructed(front grilles antl vent caps).
_ Explosion Rlsk • Betore installing into a solid fuel buming fireplace,the
Do not try to light any applianca. Do not close Me 91ass doors dunng appliance chimney and firebox shoultl be Inspected and cleanetl to
Do not touch any electrical switch;do not use any phone in your building. � oPe�ation. remove soot,creosote,ashes,pa�int eira nests etc.
Immediately call your gas supplierfrom a neighbor's phone.Follow their instruetions. • coma cause��compiete comoustion or • nnnuai examination or the chimney must be pertormea
If you cannot reach your gas supplier,eall the Tire department. tne gas. by a qualified agencyto ensure proper ventilation offlue
gases created by this appliance.
C.USE Of1Iy yOUf h3fld�O PUSh Ifl Of tuT ihB e85 COfISlOI kflOb.NEVCf IISE�0018.If�IIE I(f10I1 • Glass COorS mey be closetlwhenttte hearth kitis nOtbeing • Have the chimney and edjacent structure inspeCtetl
will not push in or tum by hand,do not try to repair k.Call a qualified service technician. usea. and deanea ty quaiieed Drofessionals.Hearth&Home
Foree or attempted repair may result in fire or explosion. recnnoiogles recommendsthatNFi certired orotessionals,
D.Do not use this appliance'rf any part has been under water.Immed iately cal I a qual�ed or tecnnicians untler tne airecnon of certifiea pmfessionais.
service technician to inspect the appliance and to replace any part of the control system C.Important Safeguards conduct a minimum of an NFPA Ytt Level 2 inspection
that has been underwater. • otner Fuels ottne cn�mney.
� - Al[houghyourgaslogsetlsveryrealisticinappearance, ' Replacecomponentpartsofthechimneyandfireplaceas
�LIGHTING INSTRUCTIONS A is nota real waotlbuming fire antl must not be used specified bythe pmfesslonals.
ea le 58 e InfOrtl�etion listed aboVe. for buming any fuel other than natural or propane ' Ensure all joints are proDerly engageO anE the chimney
2.Tum gas control knob clockwise to the"OFF"Position. 9as. is propeny sec�red.
- To avoid IrreDarable damage to the appliance and/or • Do not allow fans ro blow diractiy irrto the fireplace.Avoid
3.Wait 5 minutes to clear out any gas.Smell for gas,inClud'Ing nea�the flOof.If you Smell personal Injury,wooq matc�es,paper,garbageorany any drafis Mat atter bumer flame pattem.
gas,STOPI follow B in the safety instruetions above.If you do not smell gas,go to next other matenal must not ne piacea ortnrown on rop of • Do not use a nmwennsen,neat excnanger Insert oromer
Step. me logs. accessories not approvea kr use wim this apDliance.
4.Locate pilot(mounted on the right side of the bumer pan). • Appliance Satery Soiia tuNs shan not be bumad in a firepiace wnere a
5.Tum control knob counterclockwise to the"PiloY'position. - To avo�id pereonal injury,do not toucn not sunaces decoatre appiiance�is instanea.
6.Place a lit match at the pilot and simuManeously push in on the eontrol knob.This should when the appllance is opereting. • Ifglass tloors ere Oresent,tne plu�doors muat befully
ignitethepilOt. - AlwaysensurethatthefireplacescreeniscloseCwhen openeawnileap0liancelslnoperation.
Ihe appliance Is opeating.
7.OnCe the pilot lights,eontinue to depress the Control knob for 1 minuM. - Close suparvision�is necessarywhen the apPliance�is
8.After 7 minute,slowly release the control knob and it will pop back out.Pilot should remain eeing used neer children. 0 WARNING
lit.If it goes out,repeat steps 1-7. • Do nm remove any of the attached metal plates,which
If the handle does not pop out when released,stop immediately call your service conta�in�imvortant safety and operating inrormation. Fire Risk
technicianorgassupplieL • Keeptheappllanceareaclearenafreeorallcombustible _ HighTempenturcs
materials,gasollne and other flammable vapors and Keep combustible householtl items away
If the pibt will not sWy lit after several tries,tum the gas control knob to the"OFF" iiqu�ds. from appiiance.
position and call your service technician or gas supplier. Do NOT obstructcomeustion antl vemiiation
9.Tum gas control knob counterclockwise to the"ON"position.
�TO TURN OFF GAS TO APPLIANCE - A WARNING airooNOTplacecombustibleRemsontop
f or in front of aDDlianca.
DoNOTusethisappliance�anyparthasDeenuntler • Keep fumiture,draperles away from
um gas con rol knob clockwise to the"OFF"position.Do not foroe. water.Immedletery call a qualifietl service tecnnlcian appiiance.
��pi K,� to inspeclthe appliance an0 to replace any part of the
���y��n�� ontrol system antl any ge5 Control whlch has been
�TM��� ��aerwacer.
n�a s�o..�sr.mehr
Hearth 8 Home Technologies•Fireside Bumer/Hearth Kits•4004-318•Rev F 52013 11 12 Hearth 8 Home Technologies•Fireside Bumer/Hearth Kits•4004-3'IB•Rev F 520'I3
•
6 D.Troubleshooting �
Maintaining and Servicing the Appliance Wth proper Installation anE maintenance.your newCecora[rve gas aDPliance shoWC provitle years oftmuble-free service
If you Co exDenence a proElem,refer to the trouDleshooting guiEe below.Thls gulde will ass�ist you or a qualifietl service
A.Servicing YourAppliance C.Annual Inspection tecnn�ician�in tne diagnosis m DroDiems ana me corrective action ro be caken.
ymplpns PosslbkGuses CwreGWeActlon
AWARNING �WARNING +.nm.�onw�n�aramu,a �n�mc.:sn�non..n»a � r.�.k.�,,.m.iin.�nmon�.rv.m�n.a�m.
pwi. �us.a m�rq e+:i.,.��:oro�.
Riakofinjuryorpropertydamege Annual inspeclion by quall(latl technician B.ThereeairniMpasti�w. t.LpMemaxn.TumineveNekrwtmdro'PILor
Berore:ervicing: _ menaea. ws�u�.�eav.9+.K«c�n.m.cn�..�u»v+o�
• Turn off gas. Check: wro�u�roi a pms.
Tumoffelectricdytoappliance. � • Contlitionottloors,sunounasantlfmms. c.rn.ww.kmn�smma i.mmm.wm."wemcn.'aaorposaAn.�a
Dlsable remote control,if one Is present. • ObstruMions otcombustion antl ventilation �oFr posmon. apess.K..o m.m.rcn�..r m.v�b�e�m.r��ei a
Ensure appliance is completely cooled. �p��'�
Af[erServicing: • ConEitionoflogs. D.Tnepbtor�ficeisqupqetl, i.Thisrap�irrpuYnmoberMwmeaprwd
Replaceanyscreenorbartierthatwasremoved. • Conditionoffireboz. ndeiaw��qye+mnow. .,o.�.z..c.e.a�,�r.a,.r�.mcn�K.n.
Reseal antl reins[all any venting removetl for S�4 : Gasconnectionsantlfittings. �ys�ptye � �u
52NICI119. ObSItUC2i0f15 01t2ITlt1dfl0ll CdD� E.uTha,�� 1 CMckdp tlie pes wpply tine��fire lus baen
C18an: �
• Glas. 2.Tna o�opane mnk�is emqy.
• Repalr and replacement work shoultl be tlone by a • Logss z.mev�iaiqms,b�rc n.m.n.rm«o�vbamo .rneme�,�o�o�mm�ue.,ro�naa�om.V.n.
qualifiedservicetechnician. • Bumer,bumerports. wai�o�seynarter eqmorroobo». � n�y.�-iqn�p�s:iien�r�wnn.wrazn.
• AMaysshutoRthegassuppyanEmakesuretheapplianca w�n�llyrollowin9iqntl^9 a.m.r.a.w«kqim m.p�a�nam.m�a.�q�nma�n.rmo�o�q�..
Risk of: ore � ��
IscoolDeforebeglnninganyse operation. • Fire � n•m.. cm.�.�,a�«.q��im.paoiror�,�m�mnama
• Ahvays check br gas leaks after servicing. • Delayetl Ignition or explosion '�m�•m•��o��•�•�w�l•.
c.o.ro�awm.maw�p• i.ci.�km.m.�«w,a�wen.moi�m.m�nz
• Ahvayscneckforproperverrting. • ExposuretocomDustionNmes roiwws:oewn�wnme�nerm«oupeiromme�an.
• oaors .�a��.nm.reawaaoimam.n��om.vnre�«w
oi n.n.,m«a,p+.wnn.a m.a.ck►.a m m.
B.Cleaning Your Appliance m.r.,m m.wva.�wa�oim.me�o�w,p..wm
n.a�u�.�a xwv u»xme aeaeuea wnue�aw�q
Your gas logs requlre Itttle care.Keep the bumer assembly, r.,e��.rn.mr.rreaamps snouw ee prearor pu�
logs anC bumer a unding the logs clean by tamv.itna,.eplaum.m.�mocoupe.
ming or brusning wi[h a Cry palnt brush at least twice
d Y23f. J.TM pbl�n on,CN tlroro n�.R Ebckepa is paveirtlnp 1.InspectlM Wmar onfica br aEstrucEan.GII a
• The log5 beCome hagile atter buming.Take care�in �op.sroV.mnnd,m.r, yanow. qirelnifieaxrviut.cMic'un.
hdlltlllll9. iMv�MlmoO�aon. B.DafeclrvevaM. 1.ReplauNapasvaNe.CaHaWelilretl»rnce
• AM1vdys turn oR Me ges to Ne pilot before cleaning.For bcnnwian.
relighting,refer to lighting Instructions located Section 5
of these Instructions.
• AM1vayskeep�heappliantedeetandh8ehomCombustiGle
materials,gasoline,an0 ot�er fiammaEle vapors and
Ilquitls.
• Neverob5tructtheflowofcom�ustionantiventilationeir.
Keep the hont of the appliance clear o(all obstacles and
ma[erials.
• Leave clearance of at least 36 in.hom the front of the
fireplace.
• 7he alr shutter shoulE not be blocketl.
A CAUTION
Logs can get very hot.Handle only whan they are
oal
Hearth 8 Home Technologies•Flreside Burner/Hearth Kits•4004-318•Rev F 520t3 13 14 Hearth&Home Technologles•Flreside Bumer/Hearth Kits•4004318•Rev F 52013
7 Reference Materials � service Parts FIRESIDE HEARTH KITS
A.Replacement Parts H E A RT H FrH OoM S �9�^^�^99�^utactutlng Dale:8H12010
Service Pans Service Parts List E"m� Manulaefutlng Date:Aetive
FIRESIDE HEARTH KITS
H E A RT H�H O M E Explotletl Paris DIa9/am Beglnning ManulacWring Dale:81112070
te�nnolo9�et EndlnpManufae[uNngDate:Aelive / pµ��ypyonMP�rt 78NOILP 24N62P 30NGILP aly.
1 BumerPanAssem�ty SRVAGLBP'14 SRVAGLBPtB SRVAGLBP24 1
1-BumerPanAasembly 2 GrateAssem�iy SRVAGi6 SRVAG20 SRVAG24 1
18 in..26 in..JO in.
3 Vaive- SRVAF1000 SRVAF1000 SRVAF1000 1
4 'LP-PIIotAssy SRVE6tL50381 SRVE61L503B1 SRVE6�L5038� �
5 'NGPIIotAssy SRV09-1005 SRV09-1005 SRV09-1005 1
5 'ThermocoupleNGonly SRV07-1009 SRV07-t009 SRV07-1009 1
6 NG Onfice BPO-2-26 BP42-20 BP62-16 1
7 LP Orifice AM-2-07 AM-2-07 AM-2-42 t
e Regulator(LP only) SRVOB-1030 SRVO&1030 SRVOB-1030 t
4-GrrteAssembly 9 ConnectorTuGe SRV3814NXN SRV38�4NXN SRV3B14NXN 1
78 in.,24 in.,30 in. 10 Valve Shieltl SRVMT805-VC SRVMT805-VC SRVMT805-VC 1
� 11 DamperStopAssembly SRV500.SC SRV500-SC SRV500-SC t
12 Regulator Heat Sh�ielC LP Onry MT�00-RC MT-B00.RC MT-800-RC 1
Santl(NGonly) SRVACCIS SRVACCIS 1
Sand(NGonly) SRVACCIS 2
� LavaRock SRVACCtO SRVACCIO t
LavaRock SRVACCIO
Vermiculite(LP only) SRVACCII SRVACCII 1
�_.�. �...-�,� �� Vermiculite(LP only) SRVACC'11 SRVACCII SRVACC'11 2
9 GlowingEmbers SRVACCI2 SRVACCI2 1
GlowingEmbers SRVACCI2 2
,�2 -�� HearthKi[Install 4004-318 4004318 4004318 1
Hearth Ka Asaemblies�JATURAL
5 "Stock to Depot
Meakh Kit Assembliea-LP
i 8
fi 3�ri 1
1
7�``^�
3
nearth 8 Home 7echnolog�ies•Fires�ide Burner/Hearth Kits•4004318•Rev F 52013 15 �6 Nearth 8 Home iechnolog�ies•F�iresiCe 8urner/Hearth Klts•4004318•Rev F 52013
a
�
� service Parts FIRESIDE HEARTH KITS � service rarts FIRESIDE HEARTH KITS
H E A R T H�H O M E Expioaaa rart.paanm Beglnnlnp Manufaclutlng Dale:&11P010 H E A R T H fr H O M E Servlee Parts Llst Beglnning Manuhdutlnp Drte:8H@010
tecAnologieS EnEingManuheturinpDale:Acdve tecAnolo ieS EntlinqManufactuAn DMe:ARive
• DescrlpNonMPart STSP18N0 STSP2�N0 STSPIBLP STSP2ILP Qty.
1 BurnerPanAssembly SRVOBRI4ST SRVOBP-�BST SftVOBP-�4ST SRVOBP-18ST 1
1-BumerPanAsaembly 2-GrateAssembly 2 GrateAssembly SRVS7G20 SRVSTG20 SRVSTG20 SRVSTG20 1
18 in.,24 in.,30 in. 78 in,24 in.,30 in. 3 Valve- SRVAF1000 SRVAFt�00 SRVAF1000 SRVAF�000 1
4 'PIIotAssy-LP SRVE6�L503B1 SRVEfi1L503B1 1
5 'PllotAssy-NG SRV09-'1005 SRV09-1005 �
5 'Thermocouple SRV07-'1009 SRV07-1009 1
6 NGOrifiCe BPO-2-24 BP62-20 �
��' 7 LP Orifce AM-2-45 AM-2-02 1
. .. 8 Reguletor(LPonly) SRVOB-1030 SRVOB-�030 1
9 CannectorTube SRV3814NXN SRV3814NXN SRV38t4NXN SRV3814NXN 1
10 Valve Sh�ield SRVMT805-VC SRVMT805-VC SRVMT805-VC SRVMT805-VC 1
. ��;, 11 DamperStopAssembly SRVSOOSC SRV500-SC SRV500-SC SRV500SC 1
12 RegulatorHeatShield LPOnIy SRVMTA00-RC SRVM7-800.RC SRVM7-800-RC SRVM7-800-RC 1
Sand SRVACCIS SRVACCIS 2
� Vermicullte SRVACCII SRVACCII 2
F_ � s LavaRock SRVACC'IO SRVACCIO SRVACCIO SRVACCIO 2
9 t Glowing EmDers SRVACCI2 SRVACCI2 SRVACC'12 SRVACC'I2 2
� �
10
� Hearth Kttlnstall 4004-318 400<318 4004-318 4004-318 1
Valve Auembliec
See Thru Hearth Kk Assemblia-NG �
/ �y �� 'Stock to Depot
i
� J
��� �� See Thru Hearth Kk AssemDlies-LP
6
4 8
3
3.
7
Hearth 8 Home Technologies•Fireside Burner/Hearth Kils•4004318•Rev F 52013 17 18 HearM 8 Homa Tachnologies•Fireside Bumar/Hearth Krts•4004-318•Rev F 52013
B.Optional Components
HwM 6 Ha�r T�dmoloplu Inc.
LIMRED LIFETIME WARRANTY
HeaAh S Hortis TBchndopbs Ine.,on bshaN oi ils hearth barMs('FiHT')�e�dxMs the folbwing wetraMy!a
MHT gea,wood.pellet,ooel end eleeMc heerth appllances that m pu�hasad from an HHT wtl�orlaetl tlmlx.
REM-KIT , on IG4 From manual to variable flame wrt�optional remo[e wrtrol �
ILSK100.KIT �Conv on IGt-From m nual lo onloHwrth a log switcn HHT WBIq11b OD IMa1p11W oW11yI pf�h9 HHT�ppllYnGe el Vq�ly d InWII�110n,ilq 00ltry 4f1�MM yqnp pwnynhip
�LMK-SP �conve on kn-For leR sitle piping d iM eppllanca ot Ma�IN o}InWllatlm wMln two yeeis follahp Me C�b d arlytial pumhw,IM 1M HHT eppllemx
MII ha hee irom deMn in rtrOerlWs end woAu�rrWtlp at Me tlme d rtrn�fws.Msr Yqlell�tlm,it mvered mmpo
n.,�s menurace,na ny HHr an round m ea asrwNe In rr�bhls w waiwiwshlv dunq ma epp�loae warra+q aMod.
HHT wlll,at Ms optlm,rapM a npere Ihe oovereC oompu�enp.HHT,at Ib wm dwNbn,may NI y dMclnrps all d b
oblga0dy ui0er wdi wart�ntle,by iepl�dnp IAe pratlucl IbNf or rMundlrg IM verMkO purdr�e qin oI1M poEutt
IhNf Tha mmdmun�mourrt remwa6l.unEar thb werterM1y h I Imibd b tha W Rluea pMe af Cw Y�ucl.mr r�ar�anq
4 whJx3 b caMMbns�mclWdw wM IYnIMWm n tle�aiDeA belaw.
WARAANTY PERIO�:
Wana�y'wvaspe baGlro on tha tlab d Im011albn.In IM caw of new hortw conMncllm.wanvMY cowraW beplro on
the dats dfi�st oxipswy d ths tlMellinp a�bc monCu el0er Ms aals d tM qotluct Dy en InOepsMaO,aWwrizetl MHT
0e�ler/tlbNbuEor,whtl�er occtn earl ler.Tw w�rmly th�ll m�mie�we rq leter tlir�24 rtpnUq PoIIowYp the da0s d
poduct Mlprtqrrt M1om HHT,rprdlaw ol tlw IMyllotlpn a omipanry Opte.The rvrtarrty perlod br poN ond IaDor for
wvs�d mrtppwr�b I�P�duaC t�R�e follaMq IeWs.
Ths arm•umlhtl Llfatlnw•In tne hb�e ENow k aalln�e m:20 Yeeis ham tM be0�nninp CaOe awamnry myarpe 1or
0��DDRvcs��nU to ys��rtom tle bepinnhp Gee dwvnMY�4��,D��el nE wN�aplriar.7hse
tlrtr PMbAs rMIBCt BN minimum ups,btl uNM1�I IIvM dtlr dwipro[sE oDmponsnh undM nomrl opr�lkp mnditiarn.
womny Pornd Mlfi L4nutac��ne ppllano�s ana vanarq ..
COmpoirorRs Cove�e0
P�N ' LaCv Gee WOOE Pspsl w� Coel ElsCtrit VanlFq ��.
NI pMs aM materlal�xcepl as��..
1 var 7( X X X X X X ��C��'
ExGuaiaiu.antl_Imlhtl�n �:
Ib
x x x qnrters,ebctror�c componems,�.
2�� and lasa
% X X X X Fa• ns bC
X Nodea I
Fi
5 �7 % X Ceei anC
7yeas 7yNn % X X MirRdd:�Wf.
T
10
'; �Y� X eumas.bp�erM'shsCbry �,
L'miled�3 yean 7( X X % X Flraoa na�eet excna1pel ���.
90 Day6 X X X X X X X AI�pplsC4ma'rt W�b j
tl warrar
Sw anEbary.�id�s�or�,antl IMhYWs on next Ve9e.
Hearth 8 Home Technologies•FiresiOe Bumer/Hearth Kits•4004-318•Rev F 520�3 19 20 Hearth 8 Home Technologies•Fireside Burner/Hearth Kits•4004-318•Rev F 52013
P
A �
+( I/ D.Contact Infortnation ,'
HEARTH£s-HOME
technologies' A
WARRANTY CONDITIONS: ��
• This wartanry only covers HHT appliances that are purchasetl through an HHT aulhonzeA aealer or AisVibutor.A list of
HHT a��ho�=ad daa�e��s a�a,�a�a o��,e HHT b,��dad wabs,�es H E A R T H �H O M E
• This wananty i5 only valid while Ne HHT appliance ramalns al Ne site of onginal installa�ion.
• Contact your installing Oealer for warranry senice.It ihe installing dealer is unable to provide necessary parts,contacl t e c h n o I o g i e s�
ihe nearest HHT authorized dealer or suOPlier.Additional service fees may apply If you are seeking wananry service
from a dealer other than ihe dealar from whom you onginaly purchased the producl.
• Check with your dealer in advance for any wsts to you when arranging a warranry call.Tavel and shipping charges
for pans are not wvered by[his wartanry.
WARRANTY EYCLUSIONS:
This wartanty does not wver the following:
• Changes�n surtace rn�snes as a resun or normal use.As a nea6ng eppiiance,some changes���color of intenor antl Please contact your Hearth 8 Home Technologies dealer with any queslions or concems.
exlenor surtace finishes may occur.This is not a Aaw and is not covered under wartanry.
• Damage to pnnted,plated,or enameleG surtaces caused by fingerpnnts,accidents,misuse,scratches,mettad items, For t�e number of your nearest Heart�8 Home Technologles dealer,please call 1-800-927E841 or 1-888-027-3973.
or olher eatemal sources anE resitlues left on the platetl surfaces(rom the uu of abrasive Geaners or Dalishes.
• Repair or replacement of Darts that are subjea to nortnal wear and tear dunng the wananry period These parts
inUuOe�.Oainl,wood,pellet and coal gaskets;frebncks;grates:Oame guides;and the diswloration of glass. -NOTES-
• Mirwr expansion,contraction,or movement of certain parts causing noise.Theu wnditlons are normal and com-
plaints relatBd to th�is noise are not coveretl by this warranry.
• Damages resulting from:(1)failure to Install.ope2te,or maintain t�e appliance in accordanca with the inslallation
instructions,operating instructions,and listing agent itlen[ifcation label fumished with the appliance;(2)failure lo
iretall Ne appllance in accortlance wit�local building coEes;(3)shipping or Improper handling;(4)improper opera-
tion,abuse,misuse,continueE operatbn with 4ama9e0,corrodetl or failed comDonents,accident,or impropehy/
nactly pertormed repairs;(5)environmental wnEitions,InaEequate ventilation,negative pressure,or tlrafting
wused by tightly sealed constructions,insuRcient make-uD air supply.or hantlling tlevices such as ezhaust fans or
forced air/umaces or other such causes;(6)use of fuels other than Nose sDecifed In the operating Inswctions;(7)
nsfallation or use of components not supplied with the appliance or any other components no�expressly authonzed
and approved by HHT,(8)mod�wtion ofthe appliance no�ezpressly authonzed and approveE by HH71n wnting;
an0/or(9)Intarruptions or fiuctuations of electncal powar suppry to the appliance.
• Non-MHT venting wmponents,heanh components or other accessones usetl in conjunction wit�the appliance.
• My pan of a pre-existing freplace system In whlch an Insert or a tlecorotive gas apP�'iance is installeA.
• HHT's obligation under Nis warrenry does nol extend to the eppliance's rapablliry�o heat the tlesired spece.Informa-
tion is provideA to assist Ihe cansumer and the dealer in selecting the proper appliance tor the appllcation.Consider-
ation must be given to appliance location and wnfiguratioR environmen�al contlitions,insulation antl air tightness of
ma:wa�re.
This warranty is void if:
• The aDPllance has been overvfred or operated In almospheres contaminated by chlorine,fiuonne,or other damaging CAUTION
chemiwls.Over-finng can be iCentifiac by,bu[not Ilmited to,warped plates or tubes,rust colorad cast�iron,buDDling,
acwng ana eiscobraaon or sieei or enamei nnisnes. ���( DO NO7 DISCARD THIS MANUAL O
• TheaDDllanceissubjecteCmprdongedpenodsoftlampnessorconCensation. �k �\ mportant operating• Reatl,untlerstantl• Leavethismanualwit� ��sO,t,
• Therelsanytlama9etotheappllanceorothercomponentstluetoweterorweatherdamagewhichlstharesullof,but h�;b�` ana maintenance andfollowthese partyresponsibletor C,9�T
not limited to,improper chimney or venting installation. �� instructions included. instructions for safe u5e end o tion. 'P
III��� pere Q
�� installa�lon antl
LIMITATIONS OF LIA81LIN: �- operation.
• The owner's exdusive remedy end HHT's sole obligation under thls warranry,untler any other wartanry,express or
implied,or in convan,tort or otheiwise,shall be limited to replacement,repair refund,as specile0 above.In no
vent will HFfT be Ilable for any incidantal or consequential damages caused by defecis in Ihe appliance.Some states
tlo not allow BxUusi0n5 or limita�ion of inciGental or consaQuen�ial damagas,so lhese IimitaGons may not apply to you.
This wananty gives you spedfc ngMs;you may also have otlier nghls,which vary from state ro state.EXCEPT TO
THE EXTENT PROVIDED BV LAW,HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTV
SPECIFIED HEREIN.THE DURATION OF ANY IMPUED WARRANiV IS LIMITED TO DURATION OF THE
EXPRESSED WARRANTY SPECIFIED A60VE.
Hearth 8 Home Technolog�ies•Firesitle Bumer/Hearth Kits•4004-31B•Rev F 5/1013 21 22 Hearth 8 Home Technologies•Flresitle Bumer/Hearth Klts•4064-318•Rev F 520t3
' � �/� L�� V
�� �� DATE TIME
CITY OF ORONO CALLED IN --�
INSPECTION NOTI E SCHEDULED � �
PERMIT NO. ' '�� � COMPLETED
ADDRESS �n Z� �� Dc-v!� /�c+ �V �
OWNER ����-�-�d r° TEL HPE ON NE o. ��� �1�'-�(��� Z
CONTRACTOR
� DESCRIPTtON �C� �G� ���r ��S �
ty ❑ FOOTING ❑ DEMO-FINAL ❑ SEPTIC FINAL
Q ❑ POURED WALL ❑ PLUMBING RI ❑ EXCAV/GRADING/FILLING
O ❑ FOUNDATION WATERPROOF ❑ PLUMBING FINAL ❑ TREE REMOVAL
Z ❑ RADON SLAB ❑ MECHANICAL RI ❑ SITE INSPECTION
Q ❑ FRAMING ❑ MECHANICAL FINAL ❑ RATED WALLS
� ❑ INSULATION ❑ WOOD BURNER/FIREPLACE ❑ COMPLAINT
Q ❑ FINAL ❑ WATER HOOK-UP ❑ FOLLOW-UP
_ ❑ ILT-SURVEY ❑ SEWER HOOK-UP ❑ FOUNDATION/REMOVAL
DEMO-SITE EPTIC INSTALL
` OWN NTRACTOR TO MEEf YOU: YES_NO
c�., MMENTS:
� �
W
a
�
J
O
�.
�
O
�
W
�
Q
�
Z
W
�
W
�
J
d
W RK SATISFACTORY:PROCEED ❑ PROJECT COMPLEfE
� RECT WORK&PROCEED ❑ ISSUE CERTIFICATE OF OCCUPANCY
W
O COR CT WORK,CALL FOR REINSPECTION TEMPORARY
V BEFORECOVERING PERMANENT
❑CORRECTUNSAFECONDITIONWITHIN HOURS. � pHOTOTAKEN
INSPECTOR WILL REfURN
❑STOP ORDER POSTED.CALL INSPECTOF �CITATION ISSUED
❑ INSPECTION REQUIRED.CAIL TO ARRANGE ACCESS.
Call for the next inspection 24 ho in advance. 5 -46��
OwnerlContractor on site:
Inspector.
White Copyllnspector's Ffle Canary CopyfSite N tiee
� � DATE TIME `�
CITY OF ORONO CALLED IN � �
INSPECTION NOTICE SCHEDULED
PERMIT NO. 'Z.(2j I e -rn�J��OMPLETED
ADDRESS 1 n 7-� ����.T—P � �
OWNER �� ���� TELEPHONE NO. � �Z-g1 q IIn qz
CONTRACTOR ,
� DESCRIPTION �"� l ✓Z a J G G� L i�
ly ❑ FOOTING ❑ DEMO-FINAL '�✓� ❑ SEPTIC FINAL
Q ❑ POURED WALL ❑ PLUMBING RI �G1cS ❑ EXCAV/GRADING/FILLING
O ❑ FOUNDATION WATERPROOF ❑ PLUMBING FINAL (, �jt� ❑ TREE REMOVAL
Z ❑ RADON SLAB ❑ MECHANICAL RI � ❑ SiTE INSPECTION
Q ❑ FRAMING ❑ MECHANICAL FINAL ❑ RATED WALLS
� ❑ INSULATION ❑ WOOD BURNER/FIREPLACE ❑ COMPLAINT
Q ❑ FINAL ❑ WATER HOOK-UP ❑ FOLLOW-UP
_ ❑ A UILT-SURVEY ❑ SEWER HOOK-UP ❑ FOUNDATION/REMOVAL
J DEMO SITE ❑ TIC INSTALL
2 WNE ONTFiACTOR TO MEET YOU�YES_NO
y 'C MMENTS:
�
W
a
�
�
O
�
�
O
�
W
�
Q
�
2
W
�
W
�
J
W ❑WORKSATISFACTORY:PROCEED ROJECTCOMPLEfE
� ❑CORRECT WORK 8 PROCEED ❑ I UE CERTIFICATE OF OCCUPANCY
W
O ❑CORRECT WORK,CALL FOR REINSPECTION TEMPORARY
V BEFORECWERING PERMANENT
❑CORRECT UNSAFE CONDITION WITHIN HOURS. ❑ pH0T0 TAKEN
INSPECTOR WILL REfURN
❑STOP ORDER POSTED.CALL INSPECTOR �CITATION ISSUED
❑ INSPECTION REQUIRED.CALL TO ARRANGE ACCESS.
Call for the next inspection 24 h urs in advan 249-46��
OwnerlContractor on site:
Inspector. � �<
�
White Copyllnspector's File Canary CopylSite Notice